絡合鐵工藝是一種綠色的，基于Fe基催化劑的濕法氣體凈化技術，它集脫硫與硫磺回收于一體，在液相中直接將H2S轉化為單質S。
The complex iron process is a green, Fe-based catalyst based wet gas purification technology, which integrates desulfurization and sulfur recovery, and directly converts H2S into elemental S in the liquid phase.
硫化氫脫出率高（ 一步反應的脫出率99.99+% ）
High hydrogen sulfide removal rate (99.99+% for one-step reaction)
工藝簡單、安全，系統不使用任何有毒的化學物質，也不會產生任何有害的廢棄物，控制簡單，系統安全系數高
The process is simple and safe. The system does not use any toxic chemicals, nor does it produce any harmful waste. The control is simple, and the system safety factor is high
適合于產量在200公斤-20噸/天的小型硫化氫脫除裝置
Suitable for small hydrogen sulfide removal unit with output of 200 kg - 20 tons/day
適應H2S含量在0~100%
Applicable H2S content is 0~100%
操作條件為常溫
Operating condition is normal temperature
唐山綠源絡合鐵工藝反應原理：
Reaction principle of Tangshan Lvyuan complex iron process:
吸收反應：
Absorption reaction:
H2S(氣體)+ 2Fe+++ 2H+ + S °+ 2Fe++
H2S (gas)+2Fe++2H++S °+2Fe++
再生反應：
Regeneration reaction:
1/2 O2 (氣體) + H2O + 2Fe++ 2OH- + 2Fe+++
1/2 O2 (gas)+H2O+2Fe++2OH -+2Fe+++
總反應：
Total reaction:
H2S + ? O2 H2O + S°
H2S + ? O2 H2O + S°
絡合鐵脫硫優勢
Desulfurization advantages of complex iron
（1）絡合鐵催化劑，工藝處理過程簡單，采用一步法處理工藝即可快速將硫化氫直接氧化為硫單質；對各種不同濃度的H2S，其脫硫后的H2S含量可低于10ppm，清除H2S效率高。
(1) The complex iron catalyst has a simple process, and hydrogen sulfide can be directly oxidized to sulfur by one-step process; For various concentrations of H2S, the H2S content after desulfurization can be lower than 10ppm, and the H2S removal efficiency is high.
（2）系統的抗波動能力強。對于傳統的脫硫裝置，原料氣中硫化氫含量波動較大時，會造成出口凈化氣的硫化氫含量波動很大，甚至超標。絡合鐵高硫容特性，其脫硫裝置完全能自動處理以上波動情況，并不需要人為改變操作且不會影響脫硫率。
(2) The system has strong anti-fluctuation ability. For the traditional desulfurization unit, when the content of hydrogen sulfide in the feed gas fluctuates greatly, the content of hydrogen sulfide in the outlet purified gas will fluctuate greatly, even exceed the standard. Due to the high sulfur capacity of complex iron, its desulfurization device can completely deal with the above fluctuations automatically, and does not need to change the operation manually and will not affect the desulfurization rate.
（3）運行成本低。由于在脫硫過程中所使用的各種藥劑中的絡合鐵催化劑可再生循環使用且無副反應發生，只需補充少量的在脫硫過程中損失的絡合鐵催化劑，產出一噸硫磺藥劑運行成本1000-1500元。
(3) Low operating cost. As the complex iron catalyst used in various reagents used in the desulfurization process is renewable and recyclable without side reaction, only a small amount of complex iron catalyst lost in the desulfurization process needs to be supplemented, and the operating cost of one ton of sulfur reagent is 1000-1500 yuan.
（4）絡合鐵催化劑選擇性高，副鹽產生量低。在絡合鐵脫硫中，絡合鐵離子氧化硫化氫為硫磺，脫硫過程副反應少，藥劑使用壽命長。
(4) The complex iron catalyst has high selectivity and low bysalt production. In complex iron desulfurization, complex iron ions oxidize hydrogen sulfide to sulfur, resulting in fewer side reactions and long service life of the reagent.
（5）脫硫工作液硫容量高。新開發的絡合鐵脫硫劑，脫硫劑循環液的硫容量不受二氧化碳的影響，其工作硫容量高達3.3kg硫磺/m藥劑，高于國外同類技術（工作硫容量較好的為0.37 kg硫磺/m藥劑）。故使用絡合鐵脫硫劑能顯著降低循環液量，降低設備尺寸，減少投資和操作成本。
(5) The desulfurization working fluid has high sulfur capacity. The newly developed complex iron desulfurizer, the sulfur capacity of desulfurizer circulating liquid is not affected by carbon dioxide, and its working sulfur capacity is up to 3.3kg sulfur/m reagent, which is higher than that of similar foreign technologies (0.37 kg sulfur/m reagent with better working sulfur capacity). Therefore, the use of complex iron desulfurizer can significantly reduce the amount of circulating liquid, reduce the size of equipment, and reduce investment and operating costs.
（6）能脫除有機硫COS、硫醇。
(6) It can remove organic sulfur COS and mercaptan.
（7）設備尺寸小，可有效實現橇裝化。由于工作硫容量高，設備小，可有效實現橇裝化，非常適合小項目的橇裝化要求。
(7) The equipment is small in size and can be effectively skid-mounted. Due to high working sulfur capacity and small equipment, skid-mounted equipment can be effectively realized, which is very suitable for skid-mounted requirements of small projects.
（8）催化劑的安全性高，系統所采用的催化劑對環境及人體無毒無害，具有良好的環保效益。
(8) The catalyst has high safety. The catalyst used in the system is non-toxic and harmless to the environment and human body, and has good environmental benefits.
This article is dedicated by the friendship of biogas desulfurization. For more information, please click: http://m.sylsgd.com Sincere attitude. We will provide you with comprehensive services. We will continue to offer you more relevant knowledge. Please look forward to it
企業二維碼
2023-02-06
魯公網安備37011202000764號號